Mannitol

D-Mannitol

Clinical data
Trade names	Osmitrol, other
AHFS/Drugs.com	Monograph
Pregnancy category	US: C (Risk not ruled out)
Routes of administration	intravenous by mouth
ATC code	A06AD16 (WHO) B05BC01 (WHO) B05CX04 (WHO) R05CB16 (WHO)
Pharmacokinetic data
Bioavailability	~7%
Metabolism	Liver, negligible
Biological half-life	100 minutes
Excretion	Kidney: 90%
Identifiers
IUPAC name (2R,3R,4R,5R)-Hexane-1,2,3,4,5,6-hexol
Synonyms	D-Mannitol, mannite, manna sugar
CAS Number	69-65-8 Y
PubChem CID	6251
DrugBank	DB00742 Y
ChemSpider	6015 Y
UNII	3OWL53L36A
KEGG	D00062 Y
ChEBI	CHEBI:16899 Y
ChEMBL	CHEMBL689 Y
E number	E421 (thickeners, ...)
ECHA InfoCard	100.000.647
Chemical and physical data
Formula	C6H14O6
Molar mass	182.172
3D model (JSmol)	Interactive image
SMILES O[C@H]([C@H](O)CO)[C@H](O)[C@H](O)CO
InChI InChI=1S/C6H14O6/c7-1-3(9)5(11)6(12)4(10)2-8/h3-12H,1-2H2/t3-,4-,5-,6-/m1/s1 Y Key:FBPFZTCFMRRESA-KVTDHHQDSA-N Y
(verify)

Mannitol is a type of sugar alcohol which is also used as a medication.^[1][2] As a sugar, it is often used as a sweetener in diabetic food, as it is poorly absorbed from the intestines.^[1] As a medication, it is used to decrease high pressures in the eyes, seen in glaucoma, and to lower increased intracranial pressure.^[3][2] Medically, it is given by injection. Effects typically begin within 15 minutes and last up to 8 hours.^[4]

Common side effects from medical use include electrolyte problems and dehydration.^[4] Other serious side effects may include worsening heart failure and kidney problems.^[4][2] It is unclear if use is safe in pregnancy. Mannitol is in the osmotic diuretic family of medications and works by pulling fluid from the brain and eyes.^[4]

The discovery of mannitol is attributed to Joseph Louis Proust in 1806.^[5] It is on the World Health Organization's List of Essential Medicines, the most effective and safe medicines needed in a health system.^[6] The wholesale cost in the developing world is about US$1.12 to 5.80 a dose.^[7] In the United States, a course of treatment costs $25 to 50.^[8] It was originally made from the flowering ash and called manna after its supposed resemblance to the Biblical food.^[9][10]

Uses

Medical uses

Mannitol is used to reduce acutely raised intracranial pressure until more definitive treatment can be applied, e.g., after head trauma.

It may also be used for certain cases of kidney failure with low urine output, decreasing pressure in the eye, to increase the elimination of certain toxins, and to treat fluid build up.^[4]

Mannitol acts as an osmotic laxative^[11] in oral doses larger than 20 g,^[12] and is sometimes sold as a laxative for children..

The use of mannitol, when inhaled, as a bronchial irritant as an alternative method of diagnosis of exercise-induced asthma has been proposed. A 2013 systematic review concluded evidence to support its use for this purpose at this time is insufficient.^[13]

Mannitol is commonly used in the circuit prime of a heart lung machine during cardiopulmonary bypass. The presence of mannitol preserves renal function during the times of low blood flow and pressure, while the patient is on bypass. The solution prevents the swelling of endothelial cells in the kidney, which may have otherwise reduced blood flow to this area and resulted in cell damage.

Mannitol can also be used to temporarily encapsulate a sharp object (such as a helix on a lead for an artificial pacemaker) while it is passed through the venous system. Because the mannitol dissolves readily in blood, the sharp point will become exposed at its destination.

Mannitol is also the first drug of choice for the treatment of acute glaucoma in veterinary medicine. It is administered as a 20% solution intravenously. It dehydrates the vitreous humor and, therefore, lowers the intraocular pressure. However, it requires an intact blood-ocular barrier to work.^[14]

Food

Mannitol increases blood glucose to a lesser extent than sucrose (thus having a relatively low glycemic index^[15]) so is used as a sweetener for people with diabetes, and in chewing gums. Although mannitol has a higher heat of solution than most sugar alcohols, its comparatively low solubility reduces the cooling effect usually found in mint candies and gums. However, when mannitol is completely dissolved in a product, it induces a strong cooling effect.^[16] Also, it has a very low hygroscopicity – it does not pick up water from the air until the humidity level is 98%. This makes mannitol very useful as a coating for hard candies, dried fruits, and chewing gums, and it is often included as an ingredient in candies and chewing gum.^[17] The pleasant taste and mouthfeel of mannitol also makes it a popular excipient for chewable tablets.^[18]

Analytical chemistry

Mannitol can be used to form a complex with boric acid. This increases the acid strength of the boric acid, permitting better precision in volumetric analysis of this acid.^[19]

Other

Mannitol is the primary ingredient of mannitol salt agar, a bacterial growth medium, and is used in others.

Mannitol is popularly used as a cutting agent in cocaine.^[20]

Contraindication

Mannitol is contraindicated in people with anuria, congestive heart failure, and active cerebral haemorrhage (except during craniotomy).

Production

Mannitol is classified as a sugar alcohol; that is, it can be derived from a sugar (mannose) by reduction. Other sugar alcohols include xylitol and sorbitol. Mannitol and sorbitol are isomers, the only difference being the orientation of the hydroxyl group on carbon 2.^[16]

Industrial synthesis

Mannitol is commonly produced via the hydrogenation of fructose, which is formed from either starch or sucrose (common table sugar). Although starch is a cheaper source than sucrose, the transformation of starch is much more complicated. Eventually, it yields a syrup containing about 42% fructose, 52% glucose, and 6% maltose. Sucrose is simply hydrolyzed into an invert sugar syrup, which contains about 50% fructose. In both cases, the syrups are chromatographically purified to contain 90–95% fructose. The fructose is then hydrogenated over a nickel catalyst into a mixture of isomers sorbitol and mannitol. Yield is typically 50%:50%, although slightly alkaline reaction conditions can slightly increase mannitol yields.^[16]

Biosyntheses

Mannitol is one of the most abundant energy and carbon storage molecules in nature, produced by a plethora of organisms, including bacteria, yeasts, fungi, algae, lichens, and many plants.^[21] Fermentation by microorganisms is an alternative to the traditional industrial synthesis. A fructose to mannitol metabolic pathway, known as the mannitol cycle in fungi, has been discovered in a type of red algae (Caloglossa leprieurii), and it is highly possible that other microorganisms employ similar such pathways.^[22] A class of lactic acid bacteria, labeled heterofermentive because of their multiple fermentation pathways, convert either three fructose molecules or two fructose and one glucose molecule into two mannitol molecules, and one molecule each of lactic acid, acetic acid, and carbon dioxide. Feedstock syrups containing medium to large concentrations of fructose (for example, cashew apple juice, containing 55% fructose: 45% glucose) can produce yields 200 g (7.1 oz) mannitol per liter of feedstock. Further research is being conducted, studying ways to engineer even more efficient mannitol pathways in lactic acid bacteria, as well as the use of other microorganisms such as yeast^[21] and E. coli in mannitol production. When food-grade strains of any of the aforementioned microorganisms are used, the mannitol and the organism itself are directly applicable to food products, avoiding the need for careful separation of microorganism and mannitol crystals. Although this is a promising method, steps are needed to scale it up to industrially needed quantities.^[22]

Natural extraction

Since mannitol is found in a wide variety of natural products, including almost all plants, it can be directly extracted from natural products, rather than chemical or biological syntheses. In fact, in China, isolation from seaweed is the most common form of mannitol production.^[17] Mannitol concentrations of plant exudates can range from 20% in seaweeds to 90% in the plane tree. It is a constituent of saw palmetto (Serenoa).^[23] Traditionally, mannitol is extracted by the Soxhlet extraction, using ethanol, water, and methanol to steam and then hydrolysis of the crude material. The mannitol is then recrystallized from the extract, generally resulting in yields of about 18% of the original natural product. Another method of extraction is using supercritical and subcritical fluids. These fluids are at such a stage that no difference exists between the liquid and gas stages, so are more diffusive than normal fluids. This is considered to make them much more effective mass transfer agents than normal liquids. The super- or subcritical fluid is pumped through the natural product, and the mostly mannitol product is easily separated from the solvent and minute amount of byproduct. Supercritical carbon dioxide extraction of olive leaves has been shown to require less solvent per measure of leaf than a traditional extraction — 141.7 g (5.00 oz) CO₂ versus 194.4 g (6.86 oz) ethanol per 1 g (0.035 oz) olive leaf. Heated, pressurized, subcritical water is even cheaper, and is shown to have dramatically greater results than traditional extraction. It requires only 4.01 g (0.141 oz) water per 1 g (0.035 oz) of olive leaf, and gives a yield of 76.75% mannitol. Both super- and subcritical extractions are cheaper, faster, purer, and more environmentally friendly than the traditional extraction. However, the required high operating temperatures and pressures are causes for hesitancy in the industrial use of this technique.^[22]

History

Julije Domac elucidated the structure of hexene and mannitol obtained from manna. He determined the place of the double bond in hexene obtained from mannitol and proved that it is a derivative of a normal hexene. This also solved the structure of mannitol which had been unknown until then.^{[24][25][26][27]}

Controversy

The three studies^[28][29][30] that initially found that high-dose mannitol was effective in cases of severe head injury were the subject of an investigation published in 2007.^[31] Although several authors are listed with Dr. Julio Cruz, it is unclear whether the authors had knowledge of how the patients were recruited. Further, the Federal University of São Paulo, which Dr. Cruz gave as his affiliation, has never employed him. As a result of doubt surrounding Cruz's work, an updated version of the Cochrane review excludes all studies by Julio Cruz, leaving only 4 studies.^[3] Due to differences in selection of control groups, a conclusion about the clinical use of mannitol could not be reached.

Compendial status

• British Pharmacopoeia^[32]
• Japanese Pharmacopoeia^[33]
• United States Pharmacopeia^[34]

See also

References

External links

• RXList-osmitrol