Sikorsky R-4

R-4 / Hoverfly

Comdr. Frank A. Erickson, USCG & Dr. Igor Sikorsky, Sikorsky Helicopter HNS-1 C.G. 39040
Role	Helicopter
Manufacturer	Sikorsky Aircraft
Designer	Igor Sikorsky
First flight	14 January 1942
Primary users	United States Army Air Forces United States Coast Guard Royal Air Force
Produced	1942–1944
Number built	131
Developed from	Vought-Sikorsky VS-300
Developed into	Sikorsky R-6

In this image taken in 1944, one of Langley Research Center's Sikorsky YR-4B/HNS-1 helicopters is seen in the 30 × 60 full-scale tunnel

The Sikorsky R-4 was a two-seat helicopter designed by Igor Sikorsky with a single, three-bladed main rotor and powered by a radial engine. The R-4 was the world's first large-scale mass-produced helicopter and the first helicopter used by the United States Army Air Forces,^[1] Navy, Coast Guard, and the United Kingdom's Royal Air Force and Royal Navy.

Development

The VS-316 was developed from the famous experimental VS-300 helicopter, invented by Igor Sikorsky and publicly demonstrated in 1940. The VS-316 was designated the XR-4, under the United States Army Air Forces' series for "Rotorcraft". The XR-4 made its initial flight on 14 January 1942,^[2]^[3] and was accepted by the Army on 30 May 1942. The XR-4 exceeded all the previous helicopter endurance, altitude and airspeed records that had been set before it. The XR-4 completed a 761-mile (1,225 km) cross country flight from Connecticut to Wright Field, Ohio, set a service ceiling of 12,000 feet (3,700 m), 100 flight hours without a major incident, and an airspeed approaching 90 mph (140 km/h).^[4]

The British Admiralty, having learned of the VS-300, made a ship available that had been intended to show the USN their work with autogyros and ship operations. The Empire Mersey was fitted with a 80 ft × 40 ft (24 m × 12 m) landing platform.^[5] After her loss in 1942 to a U-boat, she was replaced by the SS Daghestan.^[6] The first deck landing trials on Daghestan were carried out in 1944^[5] The British would receive two of the first eight helicopters built.

On 5 January 1943, the United States Army Air Forces ordered 29 prototypes.^[4] The first three prototypes were designated as the YR-4A and used for evaluation testing. The YR-4A benefited from a larger, 180 hp (130 kW) Warner Super Scarab (R-550-1) engine, compared to the 165 hp (123 kW) R-500-3 engine in the prototype, and a rotor diameter increased by one foot (30 cm). Evaluation of the YR-4A demonstrated a need for further improvements, including moving the tailwheel further towards the rear of the tailboom, venting the exhaust to the side instead of downward, and increasing the fuel capacity by five gallons (19 liters). These and other design changes led to the designation of later prototypes as YR-4B, which were used for service testing and flight training.

Operational history

On 22–23 April 1944, U.S. Army Lieutenant Carter Harman of the 1st Air Commando Group conducted the first combat rescue by helicopter using a YR-4B in the China-Burma-India theater.^[7] Despite the high altitude, humidity, and capacity for only a single passenger, Harman rescued a downed liaison aircraft pilot and his three British soldier passengers, two at a time.^[8] On 22–23 January 1945, another rescue by the R-4 involved several legs for refueling and navigating through passes between mountains nearly 10,000 feet (3,000 m) tall, to reach a weather station located at an elevation of 4,700 feet (1,400 m). The higher than normal altitude required a downhill run of 20 ft (6.1 m) to get airborne.^[9]

Royal Air Force Hoverfly I in use by Fairey Aviation in late 1945

While the R-4 was being used for rescues in Burma and China, it was also being used to ferry parts between floating Aviation Repair Units in the South Pacific. On 23 May 1944, six ships set sail with two R-4s on board each vessel. The ships had been configured as floating repair depots for damaged Army Air Forces aircraft in the South Pacific. When the helicopters were not being used to fly the parts from one location to another, they were enlisted for medical evacuation and other mercy missions.^[10]

In Royal Air Force service, the R-4 was called the Hoverfly.^[11] The Helicopter Training School, formed January 1945, at RAF Andover, was the first British military unit to be equipped with the helicopter. Many RAF Hoverfly Mark Is were transferred to the Royal Navy for training and one was used in 1945/46 by Fairey Aviation to develop rotor systems for their Gyrodyne helicopter.

Variants

Sikorsky R-4B at National Museum of the United States Air Force

Some R-4s had the tail wheel located at the extreme aft end of the boom near the tail rotor while others had it positioned at the midpoint of the boom. Additionally, some had short "stub" exhaust pipes from the engine while others had a much longer one which extended vertically and then aft above the main landing gear struts.

XR-4: One prototype Model VS-316A with a crew of two and dual controls, 165 hp R-500-3 engine, became XR-4C
YR-4A: Version with larger rotor diameter and a 180 hp R-550-1 engine; three built.

YR-4B at Langley

YR-4B: Version with detailed changes; 27 built for development testing followed by a further batch of 14, seven to US Navy as HNS-1s.
R-4B: Production version with 200 hp R-550-3 engine; 100 built including 20 for the US Navy and 45 for the Royal Air Force.
XR-4C: Prototype XR-4 re-engined with 180 hp R-550-1 engine with the larger YR-4A type rotor.
HNS-1: Three YR-4Bs and 22 R-4Bs transferred to the US Navy; two diverted to the United States Coast Guard.^[12]
Hoverfly I: UK military designation of the R-4 for the Royal Air Force and Royal Navy; 52 delivered and one later transferred to the Royal Canadian Air Force.
Sikorsky S-54: An R-4B modified with an observers seat aft of the main rotor gearbox for trials.

Operators

United Kingdom

Army Air Corps
- 1901 Flight AAC
Fleet Air Arm^[13]
- 703 Naval Air Squadron/Air Sea Warfare Development Unit^[14]
- 705 Naval Air Squadron^[14]
- 771 Naval Air Squadron^[15]
- Royal Naval Flying School^[14]
Royal Air Force^[16]
- Helicopter Training Flight originally part of 43 OTU at RAF Andover^[17]
- No. 529 Squadron RAF^[15]
- No. 657 Squadron RAF^[18]

United States

Aircraft on display

United Kingdom

Hoverfly Mk.1, KL110 (painted as KK995) at the Royal Air Force Museum London. Supplied under lend-lease, it arrived in Britain in February 1945. It flew with the RAF, later the Royal Navy, until 1951. It was used by the College of Aeronautics, Cranfield until it was presented to the RAF museum in 1966.^[21]

United States

XR-4C prototype, the Smithsonian Museum's Steven F. Udvar-Hazy Center
R-4B (s/n 43-46506) is on display at the National Museum of the United States Air Force at Wright-Patterson AFB near Dayton, Ohio. It was donated by the University of Illinois in 1967.^[22]
R4-B, serial number 43-46503, is on display at the New England Air Museum, located next to Bradley International Airport, Windsor Locks, CT.^[23]
National Museum of Naval Aviation in Pensacola, Florida. Exhibit is an HNS-1 Hoverfly (Bureau Number 39047) - On indoor static display in US Coast Guard markings.
Army Aviation Museum at Fort Rucker, Alabama. U.S. Army R-4B Hoverfly (Serial Number 43-46592) and R-6A Hoverfly II (Serial Number 43-45473) on indoor static display.^[24]
Yanks Air Museum in Chino, California has an R-4B (Serial Number 43-46534) in their restoration hangar.^[25]

Vought-Sikorsky XR-4C, Steven F. Udvar-Hazy Center
RAF Museum
R-4B Hoverfly, US Army Aviation Museum
US Air Force Museum

Specifications (R-4B)

General characteristics

Crew: 1
Capacity: 1
Length: 33 ft 8 in (10.2 m)
Rotor diameter: 38 ft (11.5 m)
Height: 12 ft 5 in (3.8 m)
Empty weight: 2,098 lb (952 kg)
Loaded weight: 2,581 lb (1,170 kg)
Powerplant: 1 × Warner R-550 piston, 200 hp (149 kW)

Performance

Maximum speed: 75 mph (120 km/h)
Cruise speed: 65 mph (105 km/h)
Service ceiling: 8,000 ft (2400 m)

References

Notes

↑ "Fact Sheet: Sikorsky R-4". National Museum of the United States Air Force. Retrieved: 26 September 2010.
↑ Gunston 2005, p. 88.
↑ Mondey 2005, p. 29.
1 2 McGowen 2005, p. 29.
1 2 "Britain's Test Pilots, No. 17 Wing Cdr. Reginald Alfred Charles Brie", Flight, 12 December 1946: 643
↑ Cocker 2008, p. 114.
↑ Dorr, Robert. History in Blue, Air Force Times, 22 March 2004.
↑ McGowen 2005, p. 34.
↑ Williams 2005, pp. 30–31.
↑ Williams 2005, p. 31.
↑ Flight 1946
↑ Drucker, Graham. "Sikorsky R-4B Hoverfly (HNS)". www.fleetairarmarchive.net. Retrieved 31 March 2013.
1 2 "R-4/H-4". globalsecurity.org. 2014. Retrieved 21 October 2014.
1 2 3 Howard/Burrow/Myall 2011, pp. 3-9
1 2 James 1991, p. 306.
↑ "Helicopters for training", Flight, 5 July 1945, retrieved 21 October 2014
↑ Sturtivant 2007, p. 203
↑ Jefford 1988, p. 135.
↑ "S-47/R-4 Helicopter". sikorskyarchives.com. Retrieved 21 October 2014.
↑ "History of Coast Guard Aviation pg. 25" (PDF). uscg.mil. Retrieved 21 October 2014.
↑ Accession record
↑ United States Air Force Museum 1975, p. 42.
↑ http://neam.org/index.php?option=com_content&view=article&id=879 "Sikorsky R-4B (S-47) 'Hoverfly'"
↑ U.S. Army Aviation Museum Association, Inc. "Rotary Wing Collection." www.armyaviationmuseum.com, 2 January 2003. Retrieved: 25 August 2008.
↑ "Restoration Hangar." Yanks Air Museum. Retrieved: 18 January 2011.

Bibliography

Cocker, Maurice. Aircraft-Carrying Ships of the Royal Navy. Stroud, Gloucestershire, UK: The History Press, 2008 ISBN 978-0-7524-4633-2.
Gunston, Bill (1986). American Warplanes. New York: Crown Publishers Inc. ISBN 0-517-61351-4.
Howard, Lee; Burrow, Mick; Myall, Eric (2011). Fleet Air Arm Helicopters since 1943. Air-Britain Historians Limited. ISBN 978-0-85130-304-8.
James, D (1991). Westland Aircraft since 1915. London: Putnam Aeronautical Books. ISBN 0-85177-847-X.
Jefford MBE, Wg Cdr C G (1988). RAF Squadrons. A comprehensive record of the movement and equipment of all RAF squadrons and their antecedents since 1912. Shrewsbury: Airlife. ISBN 1-85310-053-6.
McGowen, Stanley S. Helicopters: An Illustrated History of Their Impact (Weapons and Warfare Series). Santa Barbara, CA: ABC-CLIO, 2005. ISBN 978-1-85109-468-4.
Mondey, David (1996). The Hamlyn Concise Guide to American Aircraft of World War II. London: Aerospace Publishing Ltd. ISBN 0-7858-1361-6.
Myall, Eric and Ray Sturtivant (ed.). The Hoverfly File. Tunbridge Wells, Kent, UK: Air-Britain (Historians) Ltd., 1998. ISBN 0-85130-262-9.
Sturtivant, Ray. RAF Flying Training and Support Units since 1912, Air-Britain (Historians), England, 2007, ISBN 0 85130 365 X
United States Air Force Museum Guidebook. Wright-Patterson AFB, Ohio: Air Force Museum Foundation, 1975.
Williams, Dr. James W. A History Of Army Aviation: From Its Beginnings To The War On Terror. Bloomington, IN: Iuniverse, 2005. ISBN 978-0-595-67396-4.

External links

Wikimedia Commons has media related to Sikorsky R-4.

Sikorsky aircraft

Fixed-wing aircraft (company designations)	S-1 S-2 S-3 S-4 S-5 S-6 S-7 S-8 S-9 S-10 S-11 S-12 S-13 S-14 S-15 S-16 S-17 S-18 S-19 S-20 S-21 S-22 S-23 S-24 S-25 S-26 S-27 S-28 S-29-A S-30 S-31 S-32 S-33 S-34 S-35 S-36 S-37 S-38 S-39 S-40 S-41 S-42 S-43 VS-44 S-45

Fixed-wing aircraft (military designations)	C-6 C-28 JRS JR2S PS RS XBLR-3 XPBS XSS XV-2

Helicopters (company designations)	VS-300 (S-46) S-47 S-48 S-49 S-51 S-52 S-53 S-54 S-55 S-56 S-57 S-58 S-59 S-60 S-61 S-61L/N S-61R S-62 S-63 S-64 S-65 S-66 S-67 S-68 S-69 S-70 S-71 S-72 S-73 S-74 S-75 S-76 S-80 S-92/H-92 S-97 S-300 S-333 S-434

Helicopters (military designations)	SH-3 HH-3E/F R-4 H-5 H-6 H-18 H-19 H-34 CH-37 XH-39 HH-52A CH-53 CH-53E CH-53K CH-54 HH-60G HH-60J MH-60R/S SH-60B/F SH-60J/K UH-60 VH-60 RAH-66 CH-124 CH-148

Experimental aircraft	Cypher Cypher II Firefly X2 XBLR-3 XV-2

United States helicopter designations, Army/Air Force and Tri-Service systems

Numerical sequence used by USAAC/USAAF/USAF 1941–present; US Army 1948–1956 and 1962–present; US Navy 1962–present

Main sequence
(1941–1962)

Prefix R-, 1941–1948	R-1 R-2 R-3 R-4 R-5 R-6 R-7 R-8 R-9 R-10 R-11 R-12 R-13 R-14 R-15 R-16

Prefix H-, 1948–1962	H-5 H-6 H-9 H-10 H-11 H-12 H-13/J H-15 H-16 H-17 H-18 H-19 H-20 H-21 H-22 H-23 H-24 H-25 H-26 H-27 H-28 H-29 H-30 H-31 H-32 H-33 H-34 H-35 H-36¹ H-37 H-38¹ H-39 H-40 H-41 H-42 H-43 H-44¹ H-45¹

Main joint sequence
(1962–present)

1962 redesignations	OH-13/UH-13J UH-19 CH-21 OH-23 UH-25 CH-34 CH-37 HH-43

New designations	CH-46/HH-46/UH-46 CH-47 UH-48 XH-49 QH-50 XH-51 HH-52 CH-53/HH-53/MH-53/CH-53E/CH-53K CH-54 TH-55 AH-56 TH-57 OH-58 XH-59 UH-60/SH-60/HH-60/HH-60J YUH-61 XCH-62 YAH-63 AH-64 HH-65 RAH-66 TH-67 MH-68 H-69¹ ARH-70 VH-71 UH-72 H-73 to H-89¹ MH-90 H-91¹ VH-92

1962 redesignations
reusing old numbers

¹ Not assigned

USN helicopter designations pre-1962

Helicopter, Anti-submarine

Bell	HSL

Sikorsky	HSS-1 HSS-2

Helicopter, Crane

McDonnell	HCH

Helicopter, Observation

Convertawings	HOC

Hiller	HOE

Gyrodyne	HOG

Kaman	HOK

Sikorsky	HOS HO2S HO3S HO4S HO5S

Helicopter, Trainer pre-1948

Sikorsky	HNS

Helicopter, Trainer 1948-1962

Hiller	HTE

Kaman	HTK

Bell	HTL

Helicopter, Transport 1944-1962

Boeing Vertol	HRB

McDonnell	HRH

Piasecki	HRP

Sikorsky	HRS HR2S HR3S

Helicopter, Utility pre-1949

McDonnell	HJD

McDonnell	HJH

Piasecki	HJP

Sikorsky	HJS

Helicopter, Utility 1950-1962

Kaman	HUK HU2K

Bell:	HUL

McCulloch	HUM

Piasecki	HUP

Sikorsky	HUS HU2S

Authority control	GND: 7520260-8

This article is issued from Wikipedia - version of the Sunday, January 17, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.