Toronto Rocket

Toronto Rocket
Toronto Rocket subway train at Rosedale Station
In service	2011–present
Manufacturer	Bombardier Transportation
Built at	Thunder Bay, Ontario
Family name	Movia
Replaced	H4, H5, H6
Constructed	2008–present
Number under construction	80 six-car trains on order[1][2][3]
Formation	6-car permanently coupled sets for Line 1 and 4-car permanently coupled sets for Line 4
Fleet numbers	5381-6176[4] (re-used from retired TTC vehicles, H1, H2, H4, H5, H6 subway trains, and Flyer D-901A buses, car numbers ending with 7, 8, 9 or 0 are not used)
Capacity	60–68 (seated/per car)[1] 1100 (full train, crush load)[5]
Operator(s)	Toronto Transit Commission
Depot(s)	Wilson Subway Yard Davisville Subway Yard
Line(s) served	Yonge–University Sheppard (effective summer 2016)
Specifications
Car body construction	stainless steel[6]
Car length	23.190 m (76.08 ft) [4]
Height	3.137 m (10.29 ft)[4]
Doors	8 sets (4 sets per side) per car
Maximum speed	88 km/h (55 mph)[4]
Weight	205,000 kg (202 long tons; 226 short tons) (per trainset); 34,167 kg (33.627 long tons; 37.663 short tons) per car[4]
Traction system	Bombardier MITRAC three phase AC traction motors
Acceleration	0.90 m/s2 (3.0 ft/s2) (limited)
Deceleration	1.35 m/s2 (4.4 ft/s2), 1.5 m/s2 (4.9 ft/s2) (Emergency)
Auxiliaries	120/208 VAC Battery Auxiliary
Electric system(s)	600 V DC (third rail)
Current collection method	Contact shoe
Braking system(s)	Regenerative and Pneumatic
Safety system(s)	Emergency evacuation ramps at each end of trainset
Track gauge	4 ft 10 7⁄8 in (1,495 mm) Toronto gauge

The Toronto Rocket (TR) is the newest model of subway trains on the Toronto Transit Commission's (TTC) rapid transit network in Toronto, Ontario, Canada. The trains are built by Bombardier Transportation in Thunder Bay, with designs based on Bombardier's Movia family of trains.

The TRs are the current Line 1 Yonge–University subway rolling stock. Six four-car TR trainsets are on order and will be introduced on Line 4 Sheppard in the summer of 2016 replacing the T1 trains used on that line. The TRs are the first trains in the TTC subway train rolling stock that feature full-width interior gangways allowing passengers to walk through the length of the train. They replaced Line 1's older H5 and T1 series subway trains. (The T1 trains that used to operate on Line 1 were shifted over to Line 2 Bloor–Danforth, where they replaced the older H4 and H6 series trains).

The TR trains are arranged in a six-car fixed configuration with two cab cars (allocated at the first and last cars of the train) and four non-driving cars, while other TTC train models are built in two-car mated pairs which operate in sets of two or three, forming four- or six-car trains.

Name

The trains were designated under the production name as T35A08 before the name "Toronto Rocket" was chosen through a contest open to the public.^[7][8]

Delivery

Delivery of the TR trains was expected to begin in late 2009, and they were scheduled to enter passenger service in early 2010. However, delivery was delayed by the bankruptcy of a key part manufacturer, Curtis Doors, which was to install door components for the TTC's new subway trains.^[4][5][9]

The initial order was signed in 2006 for the delivery of 234 cars, making 39 six-car fixed trains which allowed for the retirement of the H4 and H5 subway cars.

On May 6, 2010, the TTC voted to exercise a contract option with Bombardier for an additional 186 cars, making 31 six-car fixed train sets. This allowed for the retirement of the older H6 series trains, and to have enough TR trains to meet future ridership demands for the opening of the Spadina Subway extension to the Vaughan Metropolitan Centre, which was then scheduled for opening in mid-2015 (in time for the opening of that summer's Pan Am Games)^[2][10] (which has since been delayed until approximately December 2017).^[11]

A further 10 train sets (60 cars) were authorized in March 2014 to bring the total to 80 six-car train sets and 480 cars.^[3] In March 2015, the TTC reported that the T1 trains running on Line 4 would have to be replaced with TR trains before conversion of Line 1 to automatic train control (ATC) in 2020, and that TTC would report soon on the option of converting an existing six-car train to a four-car train to test One Person Only Train Operation (OPOTO) (a system that is already in place on Line 3 Scarborough).^[12]

These four-car TR trains are scheduled to enter service on Line 4 in the summer of 2016.

On October 1, 2010, the first train set (5391-5396) was delivered to Wilson Yard. It was unveiled to the public and media at Downsview station on October 14, 2010.^[13]

Between October 2010 and July 2011, the TR trains underwent a series of testing and training runs on Line 1. The first TR trainset (5411-5416) entered passenger service on Line 1 on July 21, 2011. As of spring 2015, the TR trains were being tested on Line 2, but are not operating in passenger service on that line, because the T1 trains have not outlived their service expectancy.

Features

The new TR series trains have several new features that make them more accessible and user-friendly for passengers including:

• A six-car-fixed configuration with full open interior gangways, allowing riders to move freely from one end to the other.
• An exterior blue light on each car leading to the nearest accessible seating area for passengers using mobility devices.
• Red stanchions and high visibility floor markings for visually impaired passengers.
• Antimicrobial properties on various surfaces.
• Double the number of accessible seats in each car than the T1 series subway cars, with automatic flip-up seats, which mark priority seating areas to accommodate mobility devices such as walkers, wheelchairs, bicycles and strollers. Priority seats are covered in blue velour; general seating is covered in red velour.
• Automated stop announcement system with audio and visual signs that indicate the name of the next stop, and if the station is an interchange or terminal station; along with visual arrows that indicate which side doors will open on at the next stop as well as audio announcements indicating on which side of the train doors will open on (except for terminal stations) to better assist visually impaired passengers.
• Electronic lighted route maps that indicate which stations have been served and which stations are next to follow.
• A two-way passenger assistance intercom system for passengers to communicate with the train crew in the event of an emergency.
• Built-in evacuation ramps located at the ends of the train to allow for faster and easier evacuation in the event of an emergency.
• Full-width operator cabs located at the ends of the train for the enhanced safety and security of operating personnel (as operators are allowed to access the cab unit directly from the subway platform and are not exposed to the public while performing operating duties).
• Bright orange digital LED exterior destination and train run number signs (which show three digits) at the ends of the train.
• Ceiling-mounted CCTV cameras with four in each car for passenger safety and security. Footage is recorded and can be reviewed in the event of an incident.
• Video screens displaying safety messages, TTC-related advertising and the name of the next station at the bottom.

Retrofits

In February 2013, the TTC began a trial phase with the installation of external door chimes (on each set of doorways) and additional yellow plastic straps (placed underneath the HVAC units) on the TR trains. Set 5461-5466 was the first to be retrofitted, followed by set 5851-5856 in May 2014. The rest of the TR trains fleet has the door chimes played inside the train via the public address system. The retrofitted trains have a lower pitched three-tone warning chime (F♯, D♯, B). The other TR trains have a higher pitched three-tone warning chime (G, E, C). The message "Please stand clear of the doors" overlaps the warning chime, while the message precedes the warning chime on the other TR trains. Yellow plastic straps have been phased in on all TR trains in late 2015. It has been reported that all TR trains will be retrofitted with external door chimes by approximately late 2016.^{[14][6][15][16][17]}

• 

  Gangway between cars. The poster, in French, when translated into English, reads "The Toronto Rocket is jointly financed by the Government of Canada, the Province of Ontario, and the City of Toronto."

• 

  Exterior view of the gangway

• 

  View along full length of train

• 

  Side view of cab car, seen at Wilson Yard

• 

  Operator's cab

• 

  Accessible seating position

• 

  Front view at St. George station

Financing

The TR trains are funded by the City of Toronto (via Toronto Transportation Services), the Province of Ontario (via the Ministry of Transportation), and the Government of Canada (via Transport Canada).

Interior design

The interior scheme on the TR trains is similar to the previous model, the T1 series. Unlike the older versions of subway cars, they have full-open interior gangways. The colour scheme consists of white cream walls, silver doorways, and grey floors with red floor markings for visually impaired passengers.

Rolling stock numbers

The TR train sets are numbered 5381-6176.^[1] Each set is numbered 5xx1-5xx6; car numbers ending in 0, 7, 8 and 9 are not used. These are the first trains to adopt numbering in the 6000s, since the TRs are a six-car fixed configuration (unlike previous models, which are formed in married pairs). Sets are numbered, for example, 5381-5382-5383-5384-5385-5386 and so on. At one point, two train sets had their numbers temporarily exchanged. These included sets 5781-5786 in which the exterior bore the number 5803, while train set 5801-5806 bore 5783 on the exterior car. They have since been resolved as 5803 on 5781-5786 was renumbered as 5783, and train set 5801-5806, which bore 5783, was renumbered as 5803.

Criticism

Tendering process

During the tendering process, Siemens Canada (see Siemens Modular Metro) was seen a possible competitor to the Bombardier bid.^[18][19] Councillors Karen Stintz (who later also served as TTC chair), Denzil Minnan-Wong, and Rob Ford (who became mayor in late 2010) were opposed to sole-sourcing the contract to Bombardier. They alleged that many sole-source advocates had union ties and were thus not interested in getting the best financial deal available to the city.^[20]

Mobility issues

TTC riders holding on to an overhead AC unit for stability.

In late September 2011, it was reported that some passengers with mobility devices were experiencing difficulties while entering and/or exiting the then-new TR trains. TTC officials noted that this could either be because the train was sitting too high in relation to the level of the platform or be the result of the train’s door threshold, which is not parallel with the platform and/or the number of passengers riding on the train. They were actively looking for ways to solve the problem.^[21]

To increase mobility, the train does not have centre poles, leaving standing riders with fewer places to hold onto. There are swinging handles hanging from a lateral pole along the length of each car near the ceiling, except near car ends, where an overhead ventilation unit is located.^[22]

"Teething issues"

In March 2012, TTC officials admitted that the door threshold incidents were the result of “teething issues”. Another issue that was acknowledged involves a short delay in opening of the doors when the train pulls into a station. On the older train models, the door release interlock could be triggered just before or immediately after the vehicle came to a complete stop. The TR trains must come to a complete stop with confirmation from the on board computer before the door interlock can be released and the guard can open the doors. This causes a one- or two-second delay from the time the train appears stopped and the time the doors open.^[23]

In December 2012, the TTC announced that it had demanded high-level meeting with Bombardier regarding ongoing performance problems related to "teething issues" with the doors. TTC officials admitted at the time that the new TR trains cannot move until all doors are fully closed (as with the older trains) and if the doors fail to fully close three times in a row, the TR train would require a system reboot, meaning that the train will have to be pulled out of service until it is resolved. This has led to several delays on the Yonge–University line.^[24]

Increased brightness

The TR trains feature a significantly brighter interior than previous models, which some passengers find distracting.^[25][26]

See also

• Movia
• Toronto rapid transit rolling stock

References

External links

Media related to Toronto Rocket at Wikimedia Commons

• "New Subway Train - The Toronto Rocket". Toronto Transit Commission. May 2011. Retrieved 2012-12-05. 
• "New TTC Subway Cars - Urban Toronto". Forum » Greater Toronto Discussion » Transportation & Infrastructure » New TTC Subway Cars. Urban Toronto. 2006-01-29. Retrieved 2012-12-05. 

Toronto Transit Commission Buses Blue Night Network Fleet Routes Wheel-Trans York University Busway Rapid transit  Yonge–University  Bloor–Danforth  Scarborough  Sheppard  Eglinton Rolling stock Stations Signals Streetcars 501 Queen 502 Downtowner 503 Kingston Rd 504 King 505 Dundas 506 Carlton 509 Harbourfront 510 Spadina 511 Bathurst 512 St. Clair 514 Cherry (2016) Cherry Street streetcar line Rolling stock Loops Facilities Arrow Road Bus Garage Birchmount Bus Garage Davisville Yard Eglinton Bus Garage Eglinton LRT Carhouse Greenwood Yard Hillcrest Complex Lakeshore Bus Garage Leslie Barns Malvern Bus Garage McCowan RT Yard Mount Dennis Bus Garage Queensway Bus Garage Roncesvalles Carhouse Russell Carhouse Toronto Coach Terminal Vincent Subway Yard Wilson Yard William McBrien Building Gray Coach History TTC incidents 1995 subway accident 2006 strike 2008 strike (Plans: Network 2011 Transit City The Big Move) Predecessors Williams Omnibus Bus Line (1849-1862) Toronto Street Railway (1861–1891) Toronto Railway Company (1891–1921) (Toronto and York Radial Railway (1898–1922), Metropolitan Street Railway (1885-1897)) Toronto Civic Railways (1912–1921) Hydro Electric Railways (1922-1927) Toronto Transportation Commission (1921-1953) Miscellaneous Accessibility Fares Metrolinx Personnel Font Trackage Transit Enforcement Unit Approved expansions Toronto-York Spadina subway extension Scarborough subway extension Finch West Sheppard East Proposed expansions Crosstown East Crosstown West Relief Line East Bayfront Yonge extension Unbuilt or cancelled Don Mills Eglinton West Jane Queen Scarborough Malvern Waterfront West 507 Long Branch 508 Lake Shore 521 Exhibition East 522 Exhibition West Italics indicate a project under construction