Boeing C-135 Stratolifter

C-135 Stratolifter

C-135C Speckled Trout
Role	Transport aircraft
National origin	United States
Manufacturer	Boeing
First flight	17 August 1956
Introduction	June 1957
Status	Active service
Primary user	United States Air Force
Produced	1954–1965
Number built	803
Unit cost	US$39.6 million (FY98 constant dollars)
Developed from	Boeing 367-80
Variants	Boeing KC-135 Stratotanker Boeing EC-135 Boeing NC-135 Boeing RC-135 OC-135B Open Skies WC-135 Constant Phoenix

The Boeing C-135 Stratolifter is a transport aircraft derived from the prototype Boeing 367-80 jet airliner (also the basis for the 707) in the early 1950s. It has a narrower fuselage and is shorter than the 707. Boeing gave the aircraft the internal designation of Model 717.^[1] Since the first one was built in August 1956, the C-135 and its variants have been a fixture of the United States Air Force.

Development

A large majority of the 820 units were developed as KC-135A Stratotankers for mid-air refueling. However, they have also performed numerous transport and special-duty functions. Forty-five base-model aircraft were built as C-135A or C-135B transports with the tanking equipment excluded. As is the case with the KC-135, the C-135 is also recognized as the Model 717 by Boeing.^[2]

C-135A/E/R

Fifteen C-135As, powered by Pratt & Whitney J57 turbojets, were built. In later years, almost all were upgraded with Pratt & Whitney TF33 turbofan engines and wide-span tail planes, and were re-designated C-135E. Later on, most of the C-135Es were re-engined again, using the more powerful turbofan engine, the CFM International F108 (CFM56).

C-135B

C-135B Stratolifter for VIP transport parked on the flight line at Andrews AFB

Thirty C-135Bs were built with the TF33 turbofans and wide-span tail planes from the start, and a small number remain in service in their original form. A number of these were modified for a weather reconnaissance (flying through radioactive clouds from nuclear tests or other agents) role and designated WC-135B Constant Phoenix.

C-135C

The C-135C designation applies to three WC-135B weather reconnaissance aircraft, which reverted to transport status. Most of the other C-135Bs were converted to various special mission variants following their service with the Military Airlift Command.

Although most of the remaining C-135 aircraft are used for transporting senior military leaders and other high-ranking dignitaries, the C-135C communications aircraft serves as an aerial test-bed for emerging technologies. Developmental tests using this aircraft have demonstrated the capability to fly precision approaches using a local area differential GPS system. This modified C-135 has been fitted with a millimeter wave camera and a radome to test the camera’s generation of video images of the forward scene in low-visibility conditions. The aircraft, which in the VIP/Distinguished Visitor (DV) transport role seats 14 passengers, also gives a Joint Forces Air Component Commander (JFACC) a limited ability to plan and control the simulated battle while in the air en route to the crisis area.

Speckled Trout

The C-135C Speckled Trout at Edwards Air Force Base

Speckled Trout is the official name of a combined SAF/CSAF support mission and concurrent test mission. It was also the official nickname given to a modified C-135C, serial number 61-2669, that was used by the Secretary and the Chief of Staff of the Air Force for executive transport requirements. Fully equipped with an array of communications equipment, data links and cryptographic sets, the aircraft served a secondary role as a testbed for proposed command and control systems and was also used to evaluate future transport aircraft design. The 412th Flight Test Squadron (412 FLTS) of the Air Force Material Command (AFMC) at Edwards AFB, California operated the C-135 Speckled Trout airframe and managed its test mission.

The name Speckled Trout applies to both the organization and the aircraft. The name was chosen in honor of an early program monitor, Faye Trout, who assisted in numerous phases of the project. The word "speckled" was added because Trout apparently had "a lot of freckles".

Speckled Trout acquired the C-135C, serial number 61-2669, in 1974 and retired the aircraft on 13 January 2006. An interim aircraft was in use for the Speckled Trout mission until the 2008 delivery of the current aircraft, a modified KC-135R Stratotanker serial number 63-7980 with a more modern communications architecture testbed. The current KC-135R Speckled Trout also supports additional tests and air refueling requirements that the C-135C could not.^[3]

C-135F

The C-135F were new-built aircraft used by France as dual-role tanker/cargo and troop carrier aircraft.^[4]

Variants

C-135A: Cargo/passenger variant of the KC-135A with seat for 126 passengers and powered by four J-57-P-59W engines, 18 built.^[5] It is given the Boeing model number 717-157.^[2]
C-135B: The same as C-135A but fitted with four TF-33-P-56 turbofan engines, 30 built. The five VC-135B special VIP fitted aircraft were re-designated C-135B during the Carter administration.^[5] It is given the model number 717-158.^[2]
C-135C: Three C-135B aircraft that had been modified to WC-135B standard were later de-modified but retained an air-to-air refuelling capacity so were designated C-135C.^[5]
C-135E: Three C-135A aircraft modified with four TF-33-PW-102 engines and then used as EC-135Ns were later re-designated C-135E for use in the combat support role.^[5]
C-135F: Tanker variant for France similar to the KC-135A but did not use the K prefix, 12 built.^[5] It is given the Boeing model number 717-164.^[2]
C-135K: One former EC-135K modified for VIP use for CINCPAC.^[5]
C-135FR: Eleven French C-135F tanker aircraft modified with four CFM56 engines.^[5]
C-135R

Accidents and Incidents

See the respective pages

For accidents involving other C-135 variants, see Boeing RC-135, Boeing EC-135, Boeing NC-135, and Boeing WC-135 Constant Phoenix.

. About three dozen KC-135 Stratotankers have crashed.

11 May 1964: A USAF/MATS C-135B, (Serial Number 61-0332), was on a Military Air Transport Service (MATS) flight from Fairfield-Travis AFB, CA (SUU) to Clark AB in the Philippines via Honolulu-Hickam AFB, HI (HIK). Thunderstorms were in the area as the flight approached Clark AB. An indefinite ceiling was at 300 feet and visibility was 2000 m. The crew carried out a PAR approach to runway 02. The aircraft descended below the glidepath and the crew were urged to initiate go around as the C-135 had descended below the PAR lower safety limit. By then, the co-pilot had the runway in sight and the approach was continued. On final, the undercarriage struck the perimeter fence. The airplane struck a TACAN facility, hit the ground and slid across a road, striking a cab and killing the driver. The airplane broke up and caught fire. Five of the ten crewmembers and all 74 passengers were fatally injured, along with the unfortunate cab driver.^[6]

25 June 1965: A USAF/MATS C-135A, (Serial number 60-0373), carrying 85 US Marine Corps personnel was flying from MCAS El Toro to Okinawa. Weather was poor at El Toro when the airplane was ready to depart: thick fog and light drizzle. Takeoff was accomplished at night at 01:45 from runway 34R. After takeoff, the pilot should have made a prescribed left turn. Instead, the airplane continued straight ahead. It contacted the 1,300-foot Loma Ridge, some 150 feet below the crest. The aircraft broke up and burst into flames. The crash killed all 12 crewmembers and 72 other personnel on board.^[7]

1 July 1972: A French Air Force C-135F (38473) was on a weather reconnaissance mission associated with a planned nuclear test. The aircraft lost power on one Pratt & Whitney J-57 engine and crashed into the sea near Hao Island Airport, French Polynesia (HOI/NTTO). There were no survivors among the six crewmembers.^[8]

19 March 1985: A USAF 8th AF KC-135A (Serial Number 61-0316) caught fire during ground refueling at Cairo International Airport, Egypt (CAI). The interior of the airplane was burned out and the aircraft was written off as damaged beyond repair although the wing structure was used in repairing KC-135A, Serial Number 58-0014 (which was later converted to a KC-135E). There were no injuries reported.^[9]

Specifications (C-135)

General characteristics

Crew: 3: pilot, copilot, boom operator (4 for non-PACER CRAG aircraft)
Length: 136 ft 3 in (41.53 m)
Wingspan: 130 ft 10 in (39.88 m)
Height: 41 ft 8 in (12.70 m)
Wing area: 2,433 ft² (226 m²)
Empty weight: 98,466 lb (44,663 kg)
Loaded weight: 297,000 lb (135,000 kg)
Max. takeoff weight: 322,500 lb (146,000 kg)
Powerplant: 4 × (R/T) CFM International CFM56 high-bypass turbofan engines, 21,634 lbf (96 kN) each (re-engined variants)
Powerplant: 4× (E) Pratt & Whitney TF-33-PW-102 low-bypass turbofan engines , 18,000 lbf (80 kN) each

Performance

Maximum speed: 580 mph (933 km/h)
Range: 3,450 mi (5,550 km)
Service ceiling: 50,000 ft (15,200 m)
Rate of climb: 4,900 ft/min (1,490 m/min)

References

Citations

↑ "Historical Perspective, Start of a PROUD MISSION", Boeing Frontiers, July 2006.
1 2 3 4 "KC-135". US Warplanes.net. Retrieved December 17, 2012.
↑ Air Force article on Speckled Trout retirement
↑ DoD 4120.14L, Model Designation of Military Aerospace Vehicles, May 12, 2004
1 2 3 4 5 6 7 Pither 1998, pp. 62-86
↑ http://www.aviation-safety.net/database/record.php?id=19640511-0
↑ Accident description at the Aviation Safety Network. Retrieved on 25 June 2013.
↑ http://www.aviation-safety.net/database/record.php?id=19720701-</0
↑ http://www.aviation-safety.net/database/record.php?id=19850319-0

Bibliography

Eden, Paul (ed.). The Encyclopedia of Modern Military Aircraft. London, UK: Amber Books, 2004. ISBN 1-904687-84-9.
Pither, Tony (1998). The Boeing 707 720 and C-135. England: Air-Britain (Historians) Ltd. ISBN 0-85130-236-X.

External links

Wikimedia Commons has media related to C-135 Stratolifter.

C-135 page at Globalsecurity.org

Boeing military aircraft

Fighters/attack aircraft:	PW-9/FB F2B F3B F4B XF6B P-29/XF7B XF8B P-12 P-26 818 F-15E F-22 AV-8B F-15SE F/A-18E/F EA-18G

Bombers	YB-9 XB-15 B-17 Y1B-20 B-29 XB-38 XB-39 YB-40 XB-44 B-47 B-50 B-52 B-54 XB-55 XB-56 XB-59 B-1

Piston-engined transports	C-73 C-75 C-97 C-98 C-108

Jet transports	C-135 C-137 CC-137 YC-14 C-17 C-22 VC-25 C-32 C-40

Tanker-transports	KB-29 KB-50 KC-97 KC-135 KC-137 KC-10 KC-46 KC-767

Trainers	PT-13 PT-17 PT-18 PT-27 XAT-15 T-43 T-45

Patrol and surveillance	XPB XPBB XP3B P-8 EC-135 EC-18 E-3 E-4 E-6 E-8 E-10 E-767 737 AEW&C

Reconnaissance	NC-135 OC-135B RC-135 WC-135

Drones/UAVs	CQM-121 MQ-18 X-50 ScanEagle Bird of Prey

Experimental/prototypes	X-20 X-32 X-36 X-37 X-40 X-45/Phantom Ray X-50 X-51 X-53 YAL-1 Phantom Eye

Boeing C-135 and 707 military transport aircraft

C-135 (717/739)	C-135 EC-135 KC-135 NC-135 OC-135 RC-135 WC-135

707/C-137	E-3 E-6 E-8 EC-18 C-137 CC-137 KC-137 VC-137 SAM 26000 SAM 27000 CT-49

United States military transport aircraft designations, Army/Air Force and Tri-Service systems

Army/Air Force sequence (1925-1962)	C-1 C-2 C-3 C-4 C-5 C-6 C-7 C-8 C-9 C-10 C-11 C-12 C-13¹ C-14 C-15 C-16 C-17 C-18 C-19 C-20 C-21 C-22 C-23 C-24 C-25 C-26 C-27 C-28 C-29 C-30 C-31 C-32 C-33 C-34 C-35 C-36 C-37 C-38 C-39 C-40 C-41/A C-42 C-43 C-44 C-45 C-46 C-47/T C-48 C-49 C-50 C-51 C-52 C-53 C-54 C-55 C-56 C-57 C-58 C-59 C-60 C-61 C-62 C-63 C-64 C-65 C-66 C-67 C-68 C-69 C-70/A/B/C/D C-71 C-72 C-73 C-74 C-75 C-76 C-77/B-D C-78 C-79 C-80 C-81 C-82 C-83 C-84 C-85 C-86 C-87 C-88 C-89 C-90 C-91 C-92 C-93 C-94 C-95 C-96 C-97/KC-97 C-98 C-99 C-100 C-101 C-102 C-103 C-104 C-105 C-106 C-107 C-108 C-109 C-110 C-111 C-112 C-113 C-114 C-115 C-116 C-117 C-118 C-119 C-120 C-121/F C-122 C-123/A C-124 C-125 C-126 C-127 (I) C-127 (II) C-128 C-129 C-130/J C-131 C-132 C-133 C-134 C-135/KC-135 C-136 C-137 C-138¹ C-139¹ C-140 C-141 C-142

Tri-service sequence (1962-present)	C-1 C-2 C-3 C-4 C-5 C-6 C-7/B C-8 C-9 C-10 C-11 C-12 C-13¹ C-14 C-15 C-16¹ C-17 C-18 C-19 C-20A-D/F-H C-21 C-22 C-23 C-24 C-25 C-26 C-27/J C-28 C-29 C-30¹ C-31 C-32 C-33 C-34¹ C-35 C-36 C-37A/B C-38 C-39¹ C-40 C-41 C-42¹ C-43¹ C-44¹ C-45 C-46

Revived original sequence (2005-present)	C-143 C-144 C-145 C-146

Non-sequential designations	C-767 C-880

¹ Not assigned See also: AC-47 • AC-119 • AC-130 • DC-130 • EC-130 • HC-130 • KC-130 • LC-130 • MC-130 • WC-130 • CT-39 • CT-43

This article is issued from Wikipedia - version of the Monday, November 02, 2015. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.