1957 Chevrolet

1957 Chevrolet
1957 Chevrolet Bel Air Sport Coupé
Overview
Manufacturer	Chevrolet (General Motors)
Production	1956–1957
Body and chassis
Body style	2-door sedan 2-door hardtop 4-door sedan 4-door hardtop 2-door convertible 2-door station wagon 4-door station wagon 2-door sedan delivery
Powertrain
Engine	235.5 cu in (3,859 cc) Blue Flame I6 265 cu in (4,340 cc) V8 283 cu in (4,640 cc) V8
Transmission	3-speed manual Powerglide auto Turboglide auto

The 1957 Chevrolet is a car which was introduced by Chevrolet in September 1956 for the 1957 model year. It was available in three series models: the upscale Bel Air, the mid-range "two-ten", and the "one-fifty". A two-door station wagon, the Nomad was produced as a Bel Air model. An upscale trim option called the "Delray" was available for two-ten 2-door sedans. It is a popular and sought after classic car. These vehicles are often restored to their original condition and sometimes modified. The car's image has been frequently used in toys, graphics, music, movies and television. The '57 Chevy, as it is often known, is an auto icon.^[1]

History

Initially, General Motors executives wanted an entirely new car for 1957, but production delays necessitated the 1955–56 design for one more year. Ed Cole, chief engineer for Chevrolet, dictated a series of changes that significantly increased the cost of the car. These changes included a new dashboard, sealed cowl, and the relocation of air ducts to the headlight pods, which resulted in the distinctive chrome headlight that helped make the '57 Chevrolet a classic. Fourteen-inch wheels replaced the fifteen-inch wheels from previous years to give the car a lower stance, and a wide grille was used to give the car a wider look from the front. The now famous '57 Chevrolet tailfins were designed to duplicate the wide look in the rear. Bel Air models were given gold trim: the grille, front fender chevrons, hood, and trunk script were all rendered in anodized gold. The 1957 Chevrolets did not have an oil pressure gauge or a voltmeter.^[2] The base engine was an inline 6-cylinder called the Blue Flame Six. The engine was smoother running than the V-8. Carburetion came from a single one-barrel carburetor.

"Tri-Five" 1955–1957 V8

The 1955 model year Chevrolet introduced its now-famous small-block V-8 — the first V-8 available in a Chevrolet since 1918.^[3] It has a displacement of 265 cu in (4,340 cc). Prior to 1955, Chevrolet offered an inline 235 cu in (3,850 cc) displacement in-line 6-cylinder engine only. The 1955 model, like its engine, was all new. The "shoebox" design, so named because it was the first Chevrolet to feature streamlined rear fenders, was a watershed for Chevrolet. The lightweight car, coupled with a powerful overhead valve V-8, became a showroom draw, but also thrust the company into the arena of competitive motorsports. 1955 Chevrolets went on to dominate drag racing and became a formidable force in circle track racing. In 1956, the design was lengthened somewhat in front and given a more squarish treatment; under the hood, engine power increased and a Chevrolet Corvette engine was available for the first time in a full-size passenger car. The V-shaped trim on the tail fins was filled with a ribbed aluminum insert exclusive to the Bel Air. The fuel-injected engine represented the first time that an internal combustion gasoline engine in a passenger car reached an advertised one horsepower for each cubic inch benchmark, although the Chrysler 300B beat that by a year in their 355-horsepower, 354 c.i.d dual-carburetored engine, and the Alfa Romeo Giulietta Sprint was introduced a year earlier than that (1954), with a 79 cubic inch (1290cc) engine that produced 80 hp. In NASCAR racing the 283 with its increased horsepower gave the '57 a dramatic advantage over the smaller 265 V8 the '55 and '56 had. NASCAR held the competition, especially the '55–'57 Chevrolet to a cubic inch restriction because of all the races the '57s were winning. This restriction stayed with the '55–'57 till they were grandfathered out of the lower NASCAR divisions in the 1970s as the '57 was still beating virtually all in their class.

Body styles

Body choices for 1957 included 2- and 4-door sedans (identified by the "posts" between door windows), the two-door "Sport Coupe" (a two-door hardtop - the car has no post between the front and back window when the windows are lowered), the "Sport Sedan" (a four-door hardtop), the two-door Utility Sedan, a two-door sedan with a package shelf instead of a rear seat, the Delray "club coupe", which was a 210 model 2-door sedan with a de luxe interior, two styles of two-door station wagon, the top-of-the-line Bel Air Nomad with a sloped pillar behind the hardtop door and sliding windows at the rear seat, and the basic Handyman with an upright sedan B-pillar and a C-pillar, where the four-door wagons have one, available only in 150 and 210 trims. The four-door, six-passenger station wagon, the four-door, nine-passenger station wagon (both called Townsman in the 150 series and Beauville for the Bel Air version), and the convertible. Unlike most competitors, the Chevrolet 4-door hardtop featured a reinforced rear roof structure that gave the car added rigidity and a unique appearance in silhouette. The 1957 Chevrolet was called by some a "Baby Cadillac", because of many similar styling cues to Cadillacs of the time. V8-optioned cars got a large gold "V" under the Chevrolet script on the hood and trunk lid.

The 2-door Bel Air Nomad station wagon had its own distinctive styling, mainly in the roof line and rear deck.

• 

  1957 Chevrolet One-Fifty 2-door Sedan (non-standard wheels)

• 

  1957 Chevrolet Bel Air 4-door Sedan

• 

  1957 Chevrolet Bel Air Sport Coupe

• 

  1957 Chevrolet Bel Air Sport Sedan

• 

  1957 Chevrolet Bel Air Convertible

• 

  1957 Chevrolet Bel Air Nomad 2-door 6-passenger Station Wagon

• 

  1957 Chevrolet Two-Ten Townsman 4-door 6-passenger Station Wagon

• 

  1957 Chevrolet One-Fifty Sedan Delivery (non-standard wheels)

Engines

For 1957 there were four standard engine options, a 235.5 cu in (3,859 cc) inline 6-cylinder producing 140 hp (104 kW), a 265 cu in (4,340 cc) V8 "Turbo-Fire" producing 162 hp (121 kW), and two 283 cu in (4,640 cc) V8s: a "Turbo-Fire" twin-barrel carburetor producing 185 hp (138 kW) and a "Super "Turbo-Fire" four-barrel carburetor developing 220 hp (164 kW).^[4]

Another optional engine was offered with two four barrel carburetors, the legendary "Duntov" cam and solid lifters. This engine produced 270 hp. 1957 was the first year that Chevrolet ever offered fuel injection as an option. A 283 cu in (4,640 cc) engine fitted with solid lifters, the "Duntov" cam and fuel injection was rated at 283 hp (211 kW).^[5] Fuel injection continued as an option throughout the early 1960s. However, most mechanics of the time didn't have the experience to keep the units running properly. This prompted most buyers to opt for conventional carburetion.

Options

There were many options available, most of which were designed to make the car more comfortable and luxurious. Air conditioning was offered though rarely ordered, as was a padded dash. Power steering and power brakes were available, as well as a signal-seeking AM^[5] radio and power antenna. Power windows and power seats were also available. A rear speaker could be purchased which required a separate volume knob to be installed in the dashboard, beside the radio — this rear speaker was touted as providing "surround" sound. An "Autronic eye" was offered; it was a device that bolted onto the dashboard and sensed the light from oncoming traffic, dimming the headlights automatically.^[6] One unique option was an electronic shaver, connected to the dashboard.^[7] The ‘57 radio used tubes that required only 12 volts of plate voltage and a transistor for the output stage. This lowered the power drain on the battery to an insignificant amount when the engine was off. Playing the radio with conventional tubes for extended periods occasionally drained the battery to the extent that it could not start the car. The clock was electrically self-wound and moving the hands to correct the time resulted in actually regulating the going rate. After a few corrections, the clock was remarkably accurate.

Another dashboard-mounted item was the traffic-light viewer, a ribbed plastic visor that was installed just above the speedometer. Because the roof extends so far forward of the driver, it is hard to see overhead traffic lights. The traffic light viewer captured the reflection of overhead traffic lights so that the driver didn't have to lean forward to see past the edge of the roof. A/C was also an option.^[8]

In 1957, Chevrolet started to add safety features such as "crash proof door locks^[9] "(first added in 1956), padded dash boards, safety-styled steering wheel with a recessed hub^[10] (though not as much as Ford's), seat belts(also first in 1956^[11]) and shoulder harnesses.^[12][13] However, unlike Ford, Chevrolet did not promote these safety features heavily.

1957 was also Chevrolet's first offering of a turbine transmission, known as the Turboglide. It was a design concept that Buick had developed with their Dynaflow transmission. However, due to a reliability reputation caused by its complexity, most automatic transmission buyers shunned the Turboglide in favor of the two-speed Powerglide that had been offered since 1950. At the time the Turboglide casing was the largest cast aluminum component ever put into mass production, but it never recovered from the reputation in 1957 and the option was discontinued in 1961. Manual transmissions were limited to three-speed, column shifted units (with synchromesh in second and third gear only). The Powerglide's shifter went P N D L R while the Turboglide's was P R N D Hr (although the 'Hr' was changed early in the production series to 'Gr'-Grade Retarder because of drivers' mistaken belief that 'Hr' meant High Range instead of the correct Hill Retarder.) .^[14][15] An overdrive unit was available as an option on the three speed manually shifted transmission cars. A four speed manual transmission was also offered at a price of $188.00 as a dealer installed only option. A '57 equipped with this transmission mated to the 270 horsepower engine and limited slip differential was the one to beat on the drag strip and street into the early 1960s.

Post-production popularity

1957 Chevrolet 210 2-door Sedan

1957 Chevrolet 210 2-door Sedan

From a numbers standpoint, the '57 Chevrolet wasn't as popular as General Motors had hoped. Despite its popularity, rival Ford outsold Chevrolet for the 1957 model year for the first time since 1935. The main cause of the sales shift to Ford was the fact the '57 Chevrolet had tubeless tires, the first car to have them. This scared away sales to Ford as many people did not initially trust the new tubeless design. Also Ford's introduction of an all-new body styling that was longer, lower, and wider than the previous year's offerings helped Ford sales.^[16]

However, the 1957 Ford — with the exception of the rare retractable hardtop model — is not nearly as prized by collectors today as the 1957 Chevrolet. Throughout the 1960s and 1970s, the '57 Chevrolet was a popular used car and highly prized "street machine" or hot rod in 1957 terms. It was the final year of the "shoebox" Chevrolet, as 1958 saw the introduction of a much larger and heavier "X" framed Chevrolet. The ideal size of the '57, combined with its relatively light weight compared to newer full-sized cars, made it a favorite among drag racers. The engine bay was big enough to fit GM's big-block engines, first introduced in 1958 and popularized in the 1960s by the Beach Boys in the song "409". The relatively simple mechanical attributes of the car made it easy to maintain, customize, and upgrade with components such as disc brakes and air conditioning.

The big block, however, was not what put the '57 on the map on the street scene; it was the introduction and the over-the-counter, low-priced availability of the small block, 365 horsepower 327 in 1962 that was the blockbuster that made both the '55 and '57 Chevrolet able to beat the Ford hotrods with their flathead V8s. This was a major turning point in American hot rodding: Chevrolet had claimed the street scene from Ford. The '57 Chevrolet also won 49 Grand National "cup" NASCAR races (the most of any car in NASCAR history), won the Southern 500 (in 1957, 1958, and 1959); becoming the only car to win the 500 three times. The earliest victory for a '57 Chevrolet in a titled NASCAR Grand National Series race was the 1957 Virginia 500.

The '57 also won 26 NASCAR "convertible races," more than any make, and won all three possible driver's championships. The first in convertible class and winning car in the 1959 Daytona 500 was a '57 driven by Joe Lee Johnson. The convertibles started on the outside row and were approximately ten miles an hour slower than the hardtops and sedans because of their aerodynamics. No one figured that a convertible would win the race and they didn't but wonder who was driving the top finishing convertible.

The 283 engine placed from the factory behind the centerline of the front wheels made the '57 a superior handling car on the short tracks and the dirt tracks as well. This mechanical advantage, coupled with the high revving and reliable 283, earned the '57 the nickname "king of the short tracks." With the fuel injected 283, the 150 model two door sedan version, called the "black widow," was the first car outlawed (and quickly so) by NASCAR as it proved almost unbeatable on virtually all the NASCAR tracks in early 1957. After the '57 was grandfathered out from the now "cup" division in 1960 and relegated to the lower local track sportsman divisions, they were still the car to beat for years. The '57's subsequently were used up in stock car racing at a very high rate. Surprisingly enough, the '57 Chevrolet also won a disproportionate amount of demolition derbies as well: With the radiator set back from the grille, the car was difficult to disable. The additional advantage of having the last double lined trunk, coupled with a strong frame, made it a surprisingly common winner in the demolition derbies during the late 1960s and early 1970s. By the 1970s, the '57 Chevrolet became a collector car.

Companies such as "Danchuk Manufacturing, Inc." and "Classic Chevy Club International" began selling reproduction and restoration parts. In the early 1990s, the value of a meticulously restored '57 Chevrolet convertible was as high as $100,000. Though those peaks gave way significantly after 1992, the '57 Chevrolet has held its value and is now poised to exceed the previous peak.

Although restored original examples are increasingly rare, modern customizers and restorers are creating fast, powerful, ultra-modern hot rods that are winning the '57 Chevy a whole new generation of fans. As original cars become harder to find, fiberglass and all-steel reproductions (EMI in Detroit, Michigan was the first to build restoration bodies using original firewalls with VIN numbers - the steel reproduction bodyshells are manufactured by Real Deal Steel in Sanford, Florida using reproduction sheetmetal) are making it possible for future generations to enjoy the '57 Chevrolet.

See also

• Chevrolet Bel Air

References

Forty Years of Stock Car Racing By Greg Fielden.

External links

• Car Domain: Browse '57 Chevrolets
• http://57classicchevy.com/