1968 Heathrow BKS Air Transport Airspeed Ambassador crash

1968 BKS Air Transport Heathrow crash

Twin-engined, triple-tailed, high-winged propeller-driven passenger aircraft, in profile on an airport taxiway. Natural metal finish except for airline insignia and a lengthwise stripe along the length of the fuselage.

Airspeed Ambassador G-AMAD in 1965
Accident summary
Date 3 July 1968
Summary Mechanical failure caused by metal fatigue
Site London Heathrow Airport, United Kingdom 51°28′24″N 0°27′00″W / 51.4734°N 0.4501°W / 51.4734; -0.4501Coordinates: 51°28′24″N 0°27′00″W / 51.4734°N 0.4501°W / 51.4734; -0.4501
Passengers 5
Crew 3
Fatalities 6
Survivors 2
Aircraft type Airspeed Ambassador
Operator BKS Air Transport
Registration G-AMAD

On 3 July 1968 Airspeed Ambassador registration G-AMAD of BKS Air Transport, crashed at London Heathrow Airport, damaging two parked Trident airliners as it cartwheeled into the incomplete London Heathrow Terminal 1, then under construction. Six of the eight people on board the Ambassador were killed, along with the eight racehorses being transported on it.[1] The crash was blamed on the failure of a flap-operating rod due to metal fatigue, resulting in asymmetrical lift.

Accident

The Ambassador, construction number 5211,[2] recently converted to a "horsebox" transport, was on a flight from Deauville, France to Heathrow Airport. It was transporting eight racehorses belonging to businessman William Hill together with five grooms. As the aircraft was landing on Heathrow's runway 28R the left wing dropped, and the wing tip and left landing gear touched the grass adjacent to the runway. The crew tried to increase power to go-around and climb away, but the bank angle increased. The aircraft hit two parked empty British European Airways Hawker Siddeley Tridents, knocking the tail fin off one (G-ARPI) and slicing off the entire tail section of the other (G-ARPT). The Ambassador cartwheeled following the impact and slid upside down coming up against the ground floor of the terminal building where there was an explosion.[3]

Six people on board the Ambassador died, including the flight crew and three of five grooms, along with all eight horses. The other two grooms were seriously injured as were two people on the ground. A further 29 people on the ground received slight injuries.

Of the two Trident aircraft, G-ARPT was damaged beyond economic repair and G-ARPI was subsequently repaired but was later destroyed when it crashed on 18 June 1972 in what became known as the Staines Air Disaster.[2] A Viscount (G-APKF) received slight damage.[4]

All other Ambassadors were grounded pending the result of an inquiry.[3] The starboard rod from the aircraft was tested and found satisfactory but rods from some other Ambassadors showed signs of cracking and when tested failed in a similar manner to G-AMAD's port rod. The rods on aircraft were strengthened and shown to be capable of 37,000 hours flight time.

Probable cause

The port (left) flap operating rod had failed due to metal fatigue. While the mechanism had failed, the compensating mechanism between the two sets of flaps remained intact. The port flaps had retracted but the compensator caused the starboard ones to extend further. The resulting asymmety of lift resulted in the roll to port.

The pilot probably tried to overshoot and set the flaps to the correct 10 degrees, but due to the mechanism design this was not sufficient to cause the starboard flaps to retract (which would have taken 25 seconds in any event). The Department of Transport report concluded that whatever the pilot's actions, it was "doubtful" whether an accident could have been avoided.

After the accident all Ambassadors were fitted with steel reinforcements to the flap operating rods.[1]

See also

References

  1. 1 2 Accident description at the Aviation Safety Network citing Aircraft Illustrated Vol.1, nr. 4 (Oct. 1968), p.127
  2. 1 2 Denham, Terry (1996). World Directory of Airliner Crashes. Sparkford: Patrick Stephens Ltd. pp. 85, 107. ISBN 1-85260-554-5.
  3. 1 2 "BKS Crash: Fatigue-failure" (PDF). Flight International. 11 July 1968. p. 42. Retrieved 31 August 2009.
  4. ↑ ACCIDENTS AND INCIDENTS: JUNE/JULY Flight International

Further reading

External links

This article is issued from Wikipedia - version of the Monday, October 12, 2015. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.