Lockheed Martin X-35

The Lockheed Martin X-35 was an experimental aircraft developed by Lockheed Martin for the Joint Strike Fighter Program. It was declared the winner over the Boeing X-32 and went on to enter production in the early 21st century as the F-35 Lightning II.

Development

Original F-35 Joint Strike Fighter Logo

The Joint Strike Fighter evolved out of several requirements for a common fighter to replace existing types. The actual JSF development contract was signed on 16 November 1996. The JSF program was created to replace various aircraft while keeping development, production, and operating costs down. This was pursued by building three variants of one aircraft, sharing 80% of their parts.^{[citation needed]}

The first is the F-35A, a conventional takeoff and landing (CTOL) variant. It is the smallest and lightest version, and is intended primarily to replace the U.S. Air Force's aging F-16 Fighting Falcons and A-10 Thunderbolt IIs. This is the only version with an internal gun, the GAU-22. This 25 mm cannon is an upgrade from the 20 mm M61 Vulcan carried by USAF fighters since the F-104 Starfighter. Deliveries were scheduled to begin in 2011. The F-35B is the short-takeoff and vertical-landing (STOVL) variant due to replace the U.S. Marine Corps AV-8 Harrier IIs and F/A-18 Hornets, and Royal Air Force/Royal Navy Harrier GR7/GR9s beginning in 2012. The Royal Navy will use this to replace its Harrier GR7s and the RAF replace its Harrier GR9s. The U.S. Marine Corps will use the F-35B to replace both its AV-8B Harrier IIs and F/A-18 Hornets with a design similar in size to the Air Force F-35A, trading fuel volume for vertical flight systems. Like the Harrier, guns will be carried in a pod. Vertical flight is by far the riskiest, and in the end, a decisive factor in design. Lastly, the F-35C, a carrier-based variant, will replace the "legacy" F/A-18 Hornets and serve as a stealthy complement to the F/A-18E/F Super Hornet. It will have a larger, folding wing and larger control surfaces for improved low-speed control, and stronger landing gear for the stresses of carrier landings. The larger wing area provides increased range and payload, achieving much the same goal as the much heavier Super Hornet. The U.S. Navy plans to purchase 480 JSF,^[2] with deliveries scheduled to start in 2012.

X-35C

The primary customers and financial backers are the United States and the United Kingdom. Eight other nations are also funding the aircraft's development and will decide in 2006 or later whether or not to purchase it. Total program development costs, less procurement, are estimated at over US$40 billion, of which the bulk has been underwritten by the United States. Production costs are estimated at US$102 million per unit for 2,400 units.^[3]

There are three levels of international participation. The United Kingdom is the sole 'Level 1' partner, contributing slightly over US$2 billion, about 10% of the development costs. Level 2 partners are Italy, which is contributing US$1 billion, and the Netherlands, US$800 million. At Level 3 are Canada, US$440 million; Turkey, US$175 million; Australia, US$144 million; Norway, US$122 million; and Denmark, US$110 million. The levels generally reflect the financial stake in the program, the amount of technology transfer and subcontracts open for bid by national companies, and the priority order in which countries can obtain production aircraft. Israel and Singapore have also joined as Security Cooperative Participants.^[4]

Design

Elements of the F-35 design were pioneered by the F-22 Raptor. In June 1994, Lockheed revealed that it had entered into a collaborative relationship with Yakovlev on their bid for the Joint Advanced Strike Technology competition, consisting of the purchase of design data from the Russian company; according to Jane's All the World's Aircraft 2000-2001 this was data from the cancelled Yak-141 program which employed a similar propulsion system.^[5][6][7][8] Although helmet-mounted display systems have already been integrated into some fourth-generation fighters such as the JAS 39 Gripen, the F-35 will be the first modern combat aircraft in which helmet-mounted displays will replace a head-up display altogether.^[9]

X-35 flight, video of transition to VTOL configuration, hover, take off in STOVL configuration, in-flight re-fuelling, vertical hover and landing

Instead of lift engines or rotating nozzles on the engine fan like the Harrier, the F-35B uses an innovative shaft-driven Lift Fan, patented by Lockheed Martin employee Paul Bevilaqua,^[10] and developed by Rolls-Royce.^[11] Somewhat like a turboprop embedded into the fuselage, engine shaft power is diverted forward via a clutch-and-bevel gearbox to a vertically mounted, contra-rotating lift fan located forward of the main engine in the center of the aircraft.^{[citation needed]} Bypass air from the cruise engine turbofan exhausts through a pair of roll-post nozzles in the wings on either side of the fuselage, while the lift fan balances the vectoring cruise nozzle at the tail. The F-35B powerplant effectively acts as a flow multiplier, much as a turbofan achieves efficiencies by moving unburned air at a lower velocity, and getting the same effect as the Harrier's huge, but supersonically impractical main fan.^{[citation needed]} Like lift engines, this added machinery is dead weight during flight, but increased lifting power increases takeoff payload by even more. The cool fan also reduces the harmful effects of hot, high-velocity air which can harm runway pavement or an aircraft carrier deck. Though risky and complicated, it was made to work to the satisfaction of DOD officials.^{[citation needed]}

During concept definition, two Lockheed airframes were flight-tested: the Lockheed X-35A (which was later converted into the X-35B), and the larger-winged X-35C.^[12] Both the Boeing X-32 and X-35 power plants were derived from Pratt & Whitney's F119, with the STOVL variant of the latter incorporating a Rolls-Royce Lift Fan module.^[13]

Operational history

Vertical landing (video)

Evaluation

On 20 July 2001, to demonstrate the X-35's unique capability (compared to the X-32), the X-35B STOVL aircraft took off in less than 500 feet (150 m), went supersonic, and landed vertically.^[14][15]

The contract for System Development and Demonstration (SDD) was awarded on 26 October 2001 to Lockheed Martin,^[16] whose X-35 beat the Boeing X-32.

Aircraft on display

The X-35A was converted into the X-35B for the STOVL part of the competition. It now resides at the National Air and Space Museum Steven F. Udvar-Hazy Center, near Washington Dulles International Airport in Virginia.

Following the end of the competition, the X-35C was transferred to the Patuxent River Naval Air Museum in St Mary's county, Maryland, where it reposes near the X-32B STOVL prototype.

Specifications (F-35)

Some information is estimated.

X-35A being refueled in-flight by a KC-135 Stratotanker

Data from Lockheed Martin^[17]

General characteristics

• Crew: 1
• Length: 50 ft 6 in (15.37 m)
• Wingspan: 35 ft 0 in (10.65 m)
• Height: 17 ft 4 in (5.28 m)
• Wing area: 459.6 ft² (42.7 m²)
• Empty weight: 26,000 lb (11,793 kg)
• Loaded weight: 44,400 lb (19,960 kg)
• Max. takeoff weight: 60,000 lb (27,220 kg)
• Powerplant: 1 × Pratt & Whitney F135 afterburning turbofan coupled to Rolls-Royce Lift System to give 18,000 lbf (80 kN) lift thrust
  • Dry thrust: 28,000 lbf (128 kN)
  • Thrust with afterburner: 43,000 lbf (191 kN)

Performance

• Maximum speed: Mach 1.6 (1,200 mph, 1930 km/h)
• Range: approx. 1,200 nmi (roughly 2,222 km)on internal fuel
• Rate of climb: 315m/s ()
• Wing loading: 91.4 lb/ft² (446 kg/m²)
• Thrust/weight: 0.968 with full fuel, 1.22 with 50% fuel

See also

• Fourth generation jet fighter
• Future Offensive Air System
• Joint Combat Aircraft

Related development

• F-35 Lightning II

Aircraft of comparable role, configuration and era

• Rockwell-MBB X-31
• Boeing X-32
• Yakovlev Yak-141

Related lists

• List of fighter aircraft
• List of experimental aircraft
• List of military aircraft of the United States

References

Notes

Bibliography

External links

Wikimedia Commons has media related to F-35 Lightning II.

• Official JSF homepage
• PBS NOVA: Battle of the X-Planes (JSF selection)
• F-35 JSF news articles
• Gallery
• The Australian about program difficulties, 28 June 2006.
• Data on the F-35 Joint Strike Fighter (JSF) by the Federation of American Scientists

Links to related articles v t e Lockheed Martin F-35 Lightning II Program Joint Strike Fighter program Manufacturer Lockheed Martin Aeronautics Prototypes Boeing X-32 Lockheed Martin X-35 Procurement British procurement Canadian procurement Israeli procurement Other nations' procurement Engines Pratt & Whitney F135 General Electric/Rolls-Royce F136 Rolls-Royce LiftSystem Equipment fitted AN/APG-81 AN/AAQ-37 Category  Commons v t e Lockheed and Lockheed Martin aircraft Manufacturer designations Basic Model Numbers L-1 L-2 L-3 L-4 L-5 L-61 L-7 L-8 L-9 L-10 L-11 L-012 L-131 L-014 L-015 L-016 L-017 L-018 L-019 L-020 L-021 L-022 L-023 L-024 L-251 L-026 L-027 L-281 L-029 L-030 L-031 L-032 L-033 L-034 L-035 L-361 L-037 L-381 L-391 L-040 L-041 L-042 L-044 L-045 L-049 L-050 L-051 L-052 L-060 L-061 L-062 L-075 L-080 L-081 L-082 L-083 L-084 L-085 L-086 L-087 L-088 L-089 L-090 L-091 L-092 L-093 L-094 L-092 L-099 L-100 L-133 L-140 L-141 L-193 L-245 L-246 L-300 L-301 L-329 L-351 L-382 L-500 L-645 Lockheed-California Temporary Design Numbers CL-282 CL-288 CL-295 CL-320 CL-325 CL-329 CL-346 CL-379 CL-400 CL-407 CL-475 CL-595 CL-704 CL-760 CL-823 CL-901 CL-915 CL-934 CL-981 CL-984 CL-985 CL-1026 CL-1195 CL-1200 CL-1400 CL-1600 CL-1700 CL-1800 CL-1980 Other projects SR-72 By role Airliners and civil transports Vega Sirius Altair Orion Electra Electra Junior Super Electra Lodestar Constellation (L-049 L-649 L-749) Super Constellation (L-1049 L-1249) Starliner Saturn Electra L-402 JetStar L-100 L-1011 Military transports Y1C-12 Y1C-17 Y1C-23 Y1C-25 C-36 C-37 C-40 C-56 C-57 C-59 C-60 C-63 C-66 C-69 UC-85 UC-101 C-104 C-111 C-121 C-130 / C-130J / HC-130 / KC-130 / LC-130 / MC-130 C-139 C-140 C-141 C-5 JO XRO R2O R3O XR4O R5O R6O / R6V R7O / R7V R8V / GV / UV TriStar Attack and bombers Y1A-9 A-28 A-29 XB-30 B-34 B-37 AC-130 A-4AR F-117 FB-22 Drones/UAVs Q-5 Q-12/D-21 AQM-60 MQM-105 P-175 RQ-3 RQ-170 See also: DC-130 EW and reconnaissance O-56 F-4 F-5 F-14 YO-3 EC-121 EC-130 / EC-130H WC-130 EP-3 RB-69 U-2 / TR-1 A-12 SR-71 PO / WV XW2V Fighters XFM-2 XPB-3 YP-24 P-38 XP-49 XP-58 P-80 F-80 XF-90 F-94 F-97 F-104 (F-104 variants) YF-12 F-16 YF-22 F-22 F-35 FO XFV Helicopters CL-475 XH-51 AH-56 VH-71 Maritime patrol PBO PV P2V P-2 P3V P-3 P-7 S-3 CP-122 CP-140 Trainers AT-18 T-33 T-40 TO / TV T2V / T-1 Experimental M-21 NF-104A QT-2 Senior Prom XC-35 XF-104 VZ-10 / XV-4 X-7 X-17 X-26B X-27 X-33 X-35 X-44 X-55 X-56 Names Air Express Aquila Altair Aurora Big Dipper Blackbird Chain Lightning Cheyenne Constellation L-049 L-649 L-749 Constitution Electra (Model 10) Electra (Model 188) Electra Junior Excalibur Explorer Fighting Falcon Galaxy Have Blue Hercules Hudson Hummingbird JetStar Kestrel Kingfisher Lightning Lightning II Little Dipper Lodestar Neptune Orion (Model 9) Orion (P-3) Polecat Raptor Saturn SeaStar Senior Prom Sentinel Shooting Star Sirius Starfighter Starfire Starlifter Starliner Super Constellation L-1049 L-1249 Super Electra Super Galaxy Super Hercules T-Bird TriStar Vega Ventura Viking Warning Star 1 Not assigned. v t e USAF / Joint Service experimental aircraft (X-plane) designations since 1941 1–25 X-1 X-2 X-3 X-4 X-5 X-6 X-7 X-8 X-9 X-10 X-11 X-12 X-13 X-14 X-15 X-16 X-17 X-18 X-19 X-20 X-21 X-22 X-23 X-24A / B X-25 26–50 X-26 X-27 X-28 X-29 X-30 X-31 X-32 X-33 X-34 X-35 X-36 X-37 X-38 X-39 X-40 X-41 X-42 X-43 X-44 X-45 X-46 X-47A / B / C X-48 X-49 X-50 50– X-51 X-521 X-53 X-54 X-55 X-56 See also D-558-1 D-558-2 M2-F1 M2-F2 M2-F3 HL-10 AD-1 List of X-planes 1 Not assigned. v t e Lists relating to aviation General Aircraft manufacturers Aircraft engines manufacturers Gliders Airlines defunct Airports Civil authorities Museums Registration prefixes Rotorcraft manufacturers Timeline Military Air forces Weapons Experimental Missiles Unmanned Accidents/incidents Commercial airliners by location Fatalities by death toll General aviation Military Records Airspeed Altitude Distance Endurance Firsts Large Most-produced aircraft Most-produced rotorcraft