Ballistic gelatin

From Wikipedia, the free encyclopedia

This article includes a list of references or external links, but its sources remain unclear because it lacks in-text citations.
You can improve this article by introducing more precise citations.

Ballistic gelatin is a solution of gelatin powder in water. Ballistic gelatin closely simulates the density and viscosity of human and animal muscle tissue, and is used as a standardized medium for testing the terminal performance of firearms ammunition. While ballistic gelatin does not model the structure of the body, including skin and bones, it works fairly well as an approximation of tissue and provides similar performance for most ballistics testing. Ballistic gelatin is used rather than actual muscle tissue due to the ability to carefully control the properties of the gelatin, which allows consistent and reliable comparison of terminal ballistics.

1 Preparation
2 Uses
3 See also
4 Notes
5 References
6 External links

[edit] Preparation

The most commonly used formula: "10% ballistic gelin", is prepared by dissolving 1 part 250 bloom gelatin into 9 parts of warm water (by mass), mixing the water while pouring in the powdered gelatin. It is chilled to 4° Celsius (39° Fahrenheit). An older formula used by NATO among others specifies a 20% solution, chilled to 10° C (50° F), but that solution costs more to prepare as it uses twice the amount of gelatin. In either case, a 1988 research paper recommends that the water should not be heated above 40° C (104° F), as this can cause a significant change in the ballistic performance.^[1] For detailed preparation instructions, see below.

To ensure accurate results, immediately prior to use, the gelatin block is "calibrated" by firing into it a standard .177 caliber (4.5 mm) steel BB, from an air gun over a gun chronograph into the gelatin, and the depth of penetration measured. While the exact calibration methods vary slightly, the calibration method used by the INS National Firearms Unit is fairly typical. It requires a velocity of 600 ± 10 f/s (183 ± 3 m/s), and a BB penetration between 3.25 and 3.75 inches (8.3 to 9.5 cm). 600 ft/s (180 m/s) is two to three times faster than the velocity of a BB propelled by a typical spring-air BB gun, and so where a typical BB gun might not penetrate the elastic skin of an animal, the higher velocity calibration shot will penetrate the gelatin more than might be expected.

In his book Bullet Penetration, ballistics expert Duncan MacPherson describes a method that can be used to compensate for ballistic gelatin that gives a BB penetration that is off by several centimeters (up to two inches) in either direction. MacPherson's Figure 5-2, Velocity Variation Correction to Measured BB Penetration Depth, can be used to make corrections to BB penetration depth when measured BB velocity is within ±10 m/s of 180 m/s. This method can also be used to compensate for error within the allowed tolerance, and normalize results of different tests, as it is standard practice to record the exact depth of the calibration BB's penetration.

[edit] Uses

Since ballistic gelatin mimics the properties of muscle tissue, it is the preferred medium for comparing the terminal performance of different expanding ammunition, such as hollow point and soft point bullets. These bullets use the hydraulic pressure of the tissue or gelatin to expand in diameter, limiting penetration and increasing the tissue damage along their path. While the Hague Convention restricts the use of such ammunition in warfare, it is commonly used by police and civilians in defensive weapons, as well as police sniper and hostage-rescue teams, where rapid disabling of the target and minimal risk of overpenetration are required to reduce collateral damage.

Bullets intended for hunting are also commonly tested in ballistic gelatin. A bullet intended for use hunting small vermin, such as prairie dogs, for example, needs to expand very quickly to have an effect before it exits the target, and must perform at higher velocities due to the use of lighter grain bullets in the cartridges. The same fast-expanding bullet used for prairie dogs would be considered inhumane for use on medium game animals like whitetail deer, where deeper penetration is needed to reach vital organs and assure a quick kill.

The MythBusters team is also known to use ballistics gel in many of their experiments, but not necessarily involving bullets, including the exploding implants myth, the deadly card throw, and the ceiling fan decapitation. They sometimes place real bones (from pigs) or synthetic bones in the gel to simulate bone breaks as well.