Air France Flight 4590

From Wikipedia, the free encyclopedia

Air France Flight 4590

Summary
Date	July 25, 2000
Type	Foreign object damage
Site	Gonesse, France
Passengers	100
Crew	9
Fatalities	113 (109 from aircraft, 4 on ground)
Survivors	0
Aircraft type	Aérospatiale-BAC Concorde
Operator	Air France
Tail number	F-BTSC
Flight origin	Charles de Gaulle International Airport
Destination	John F. Kennedy International Airport

Air France Flight 4590 was a Concorde flight from Charles de Gaulle International Airport near Paris, France to John F. Kennedy International Airport in New York City, New York, and operated by Air France. On July 25, 2000 it crashed in Gonesse, France. All 100 passengers and nine crew on board the flight, as well as four people on the ground, were killed.

The flight was chartered by German company Peter Deilmann Cruises and all passengers were on their way to board the MS Deutschland cruise ship in New York City ^[1][2] for a 16-day cruise to South America. Three children were on the flight. ^[3]

Contents 1 Flight 1.1 Nationalities of passengers and crew fatalities 2 Concorde grounded 3 Accident investigation 3.1 Conclusions 4 Modifications and revival 5 Criminal investigation 6 Media 7 References 8 External links

Flight

During the plane's take-off run from Charles de Gaulle Airport, a piece of titanium debris on the runway shredded a tyre, which then burst. The piece was about three centimetres wide and nearly 50 centimetres long. A large chunk of tyre (4.5 kg) struck the underside of the aircraft's wing at over 300 km/h, causing the fuel tank above the landing gear to fail from the inside out, possibly by a hydrodynamic pressure surge. Leaking fuel was ignited by an electric arc in the landing gear bay or through contact with the hot parts of the engine (the latter is disputed by the British investigators). At the point of ignition, engines 1 and 2 both surged and lost all power, but slowly recovered over the next few seconds. A large plume of flame developed; the crew then shut down engine 2 in response to a fire warning.

Having passed V₁ speed, the crew continued the take-off but they could not gain enough airspeed on the three remaining engines, because the undercarriage could not be retracted. The aircraft was unable to climb or accelerate, and it maintained a speed of 200 knots (370 km/h) at an altitude of 200 feet (60 m). The fire caused damage to the port wing. Engine 1 surged again but this time failed to recover. Due to the asymmetric thrust, the starboard wing lifted, banking the aircraft to over 100 degrees. The crew reduced the power on engines 3 and 4 to attempt to level the aircraft but with falling airspeed they lost control, crashing into the Hôtelissimo ^[4] Les Relais Bleus Hotel ^[3][5] near the airport. ^[1]

The crew was trying to divert to nearby Le Bourget Airport; accident investigators say that a safe landing with the flight path the aircraft was on would have been highly unlikely.

As the CVR transcript recorded it, the last intelligible words of the crew were (in English):

Co-pilot: "Le Bourget, Le Bourget, Le Bourget."

Pilot: "Too late (unclear)."

Control tower: "Fire service leader, correction, the Concorde is returning to runway zero niner in the opposite direction."

Pilot: "No time, no (unclear)."

Co-pilot: "Negative, we're trying Le Bourget" (four switching sounds).

Co-pilot: "No (unclear)."

Nationalities of passengers and crew fatalities

^[6]

Nationality	Passengers	Crew	Total
Germany	96	0	96
France	0	9	9
Denmark	2	0	2
Austria	1	0	1
United States	1	0	1
Total	100	9	109

Concorde grounded

Concorde had been the safest working passenger airliner in the world according to passenger deaths per distance travelled. The crash of the Concorde was the beginning of the end of its career.

A few days after the crash, all Concordes were grounded, pending an investigation into the cause of the crash and possible remedies. Air France Concorde F-BVFC was allowed to return home from its stranded position in New York, empty of passengers.

Accident investigation

The official investigation was conducted by France’s accident investigation bureau, the BEA, and it was published on December 14, 2004. It concluded that the crash was caused by a titanium strip, part of a thrust reverser, that fell from a Continental Airlines DC-10 that had taken off about four minutes earlier to Houston. This metal fragment punctured Concorde's tyres, which then disintegrated. A piece of rubber hit the fuel tank and broke an electrical cable. The impact caused a shockwave that fractured the fuel tank some distance from the point of impact. This caused a major fuel leak from the tank, which then ignited. The crew shut down engine number 2 in response to a fire warning but were unable to retract the landing gear, hampering the aircraft's climb. With engine number 1 surging and producing little power, the aircraft was unable to gain height or speed, entering a rapid pitch-up then a violent descent, rolling left. The impact occurred with the stricken aircraft tail-low, crashing into the Hotelissimo Hotel in Gonesse. ^[7] According to the report, the piece of titanium from the DC-10 had not been approved by the U.S. Federal Aviation Administration.

Conclusions

The investigators concluded that:

• The aircraft was airworthy and the crew was qualified. The landing gear that later failed to retract did not show serious problems in the past. Despite the crew being trained and certified, no plan existed for the simultaneous failure of two engines on the runway, as it was considered highly unlikely.
• The aircraft was slightly overloaded, being about a tonne too heavy.
• After reaching take-off speed, the tyre of the number 2 wheel was cut by a metal strip lying on the runway, which came from the thrust reverser cowl door of the number 3 engine of a Continental Airlines DC-10 that had taken off from the runway several minutes before. This strip was installed in violation of the manufacturer's rules.
• Aborting the take-off would have led to a high-speed runway excursion and collapse of the landing gear, which also would have caused the aircraft to crash.
• While two of the engines had problems and one of them was shut down, the damage to the plane's structure was so severe that the crash would have been inevitable, even with the engines operating normally.

Modifications and revival

The accident led to modifications being made to Concorde, including more secure electrical controls, Kevlar lining to the fuel tanks, and specially developed, burst-resistant tyres. The new-style tyres would be another contribution to future aircraft development. Just before services resumed, the September 11, 2001 attacks took place, resulting in a marked drop in customer numbers, and contributing to the eventual end of Concorde flights.^{[citation needed]} Air France stopped flights in May 2003, while British Airways ended its Concorde flights in October 2003.

Criminal investigation

On March 10, 2005 French authorities began a criminal investigation of Continental Airlines.^[8]

In September 2005, Henri Perrier, the former head of the Concorde division at Aerospatiale, and Jacques Herubel, the Concorde chief engineer, came under investigation for negligence: a report stated that the company had more than 70 incidents involving Concorde tyres between 1979 and 2000, but had failed to take appropriate steps based upon these incidents.^[9]

On 12 March 2008, Bernard Farret, a deputy prosecutor in Pontoise, outside Paris, asked judges to bring manslaughter charges against Continental Airlines and four individuals:

• John Taylor, a Continental mechanic
• Stanley Ford, a Continental maintenance manager
• Henri Perrier of Aerospatiale
• Claude Frantzen, a former employee of the French airline regulator.

Charges against Jacques Herubel were dropped.^[10][11]

Media

• The timeline and causes of the crash were profiled in an episode of the National Geographic documentary series, Seconds From Disaster.

References

External links

• Final report from Bureau d'Enquêtes et d'Analyse
• PlaneCrashInfo.Com - Data Entry on Flight 4590
• Aviation-Safety.Net - Data Entry on Flight 4590
• The Observer - this article mentions other contributing factors
• Crash report(PDF)
• Disaster, CBS News
• CVR transcript

Coordinates: 48°59′08″N, 2°28′20″E